MENU
Lake-Link Home
LOGIN
Lake-Link
LOG IN

1983 Johnson 115 v4

8/2/20 @ 8:21 PM
ORIGINAL POST
Xl1200harley
User since 8/2/20

I recently purchased a 1987 Larson 17 foot runabout with a 1983 Johnson v4 115.  This is my first boat. I’m in love with the classic boat but my issue is it will not go over 8 mph. I have found a bad coil which I replaced. New prop. Compression reads 103,105,110,114. I ran a whole can of sea foam in 1 gallon of gas which helped the idle a lot. Idles great and runs like a raped ape on muffs. Once placed in the water it won’t get out of its own way. Will rev high with the idle control but once it’s in gear it will not idle up much at all. The tach does not work but I would take a guess as to it will not rev past 1500 or 2000 rpm. I get 7-8 mph wether alone or with the family. Nothing more. I’m at a loss as to where to look next. Any help would be much appreciated.  

DISPLAYING 1 TO 10 OF 28 POSTS
FILTER OPTIONS
8/16/20 @ 3:24 PM
Plmlk
Brent Hess
MEMBER since 12/18/07

I think Harley joined Lake-link just to get advice lol

He probably got it fixed, we may never hear how the story ended!

Lots of good theories, I’m certainly interested in hearing how it ended...

The Woodlands Resort
(262) 661-3968
8/12/20 @ 8:50 PM
flint fredstone
User since 4/10/12

Daddy always said check the obvious. Did you put on a new fuel line? I had an Evinrude of that era that had fuel issues. It ran like a streak of schlitz until it didn't. Fuel line had a pin hole. New line....Vroom, Vroom! Good luck!

8/12/20 @ 7:00 PM
WelderGuy
WelderGuy
User since 12/19/10

The suspense is killin me.....

8/7/20 @ 7:30 AM
Plmlk
Brent Hess
MEMBER since 12/18/07

Any update Harley?

The Woodlands Resort
(262) 661-3968
8/4/20 @ 4:36 PM
Plmlk
Brent Hess
MEMBER since 12/18/07

When a power pack fails it’s easy to find/replace. 

But how do you troubleshoot it when it’s working? 

The Woodlands Resort
(262) 661-3968
8/4/20 @ 4:31 PM
Plmlk
Brent Hess
MEMBER since 12/18/07

Good advice CH!

The power pack is a tricky one, as it will work one minute, stop working for 10 minutes, and then start working again. 

I had a power pack intermittently fail on me, and it took me 3-months to figure out!  I’d test it and it worked in the driveway, but failed intermittently at WOT on the lake.

They can be a pistol to figure out!

It’s almost worth throwing 100 bucks at it, especially if it’s 20+ years old! 

Edit: I agree with CH, I wouldn’t play with the carbs yet, I really believe you have a cylinder dropping out.

The Woodlands Resort
(262) 661-3968
8/4/20 @ 10:25 AM
CrawlerHarness
User since 10/10/17

Thanks BrentHess.  


For Harley.....by pulling each spark plug wire (with insulated pliers or similar)....that will tell you if a cylinder is not firing.  It could be electrical, or it could be fuel/carburator related.  Either way...by pulling the wire will not only tell you if it is an issue....but which cylinder/coil pack/carburator to work on.  


Once you determine if removing plug wires shows anything....I can steer you to the next troubleshooting steps.  I wouldn't remove the carbs and play there yet....it may be your primer bulb or fuel line or fuel filter or fuel pump., etc.....yet.  Since you have spark, then it points to fuel delivery or timing.....but I don't want to jump to conclusions.  

8/4/20 @ 6:58 AM
Plmlk
Brent Hess
MEMBER since 12/18/07

One more thing regarding your power pack, and potentially running on two cylinders. 

The power pack stores voltage from the stator to release it to your ignition coil when the trigger tells it to. Often a faulty Power unit will see intermittent or no spark on cylinders and may only breakdown when your engine warms up.

This is really what I think you have going on here...

The Woodlands Resort
(262) 661-3968
8/4/20 @ 6:55 AM
Xl1200harley
User since 8/2/20

I have not been able to try pulling each plug wire individually yet. I did check for spark before I posted and I have a good blue spark on each plug. I will try tonight hopefully to pull each wire as well as pull the carb bowls and clean the jets. Didn’t get home until after dark last night. Hoping I can get out of work at a decent time tonight. Thank you everyone for so much help. I appreciate everyone’s input. 

8/4/20 @ 6:52 AM
Plmlk
Brent Hess
MEMBER since 12/18/07

Also, if you are intermittently running on two cylinders, you may be able to see some signs of that by physically inspecting the spark plugs.

If a cylinder or two is just being dragged along for the ride, the plugs will look very wet and fouled.

The Woodlands Resort
(262) 661-3968
DISPLAYING 1 TO 10 OF 28 POSTS
Advertise here
Advertise here
Please take a moment to visit our sponsors. Without them we would not be here.